Air Burners S330

New Air Burner S-330 Towable Firebox for Sale

The S330 is AirBurner's largest FireBox that can be shipped from the factory fully assembled. As it is mostly used in stationary placements at landfills and transfer stations, it is often purchased as S330E equipped with a 75 HP electric motor and easy to operate pre-programmed speed controller. As with all our machines, we offer on-site operator training and certification and internet-based remote webinar training. Training by factory instructors can be very helpful in getting a good start with your new machine and to assure safe operation in compliance with local permits and regulations.

LARGEST FULLY ASSEMBLED FIREBOX

The fully assembled portable FireBox was invented by Air Burners. Ours are the only machines tested by the U.S. EPA, the U.S. Forest Service, the U.S. Department of Energy, and the U.S. Military to prove their specifications and performance, giving you confidence our machines work. The Air Burners FireBox is the most economical and environmentally sound method of eliminating wood and vegetative waste. The FireBox will reduce your waste to approximately two percent of its original weight, leaving you with a clean carbon ash that can be turned into the local soil. With other equipment, grinding and hauling to the landfill are a big part and cost of the forest-clearing job.  With the FireBox, land clearing is much easier.  After burning all day only a small amount of ash and BioChar remain, you will be increasing soil health (USDA) if it is turned back into the soil. Job done.

The diesel-powered biomass burning machines are efficient. The 300 Series machines will only consume 3.0 gallons of diesel fuel at full operating speed, and no other fuels are required because the waste is allowed to burn naturally without the addition of hydrocarbon based fuels. The FireBox will save you money on your waste elimination. The 300 Series unit has a frame size of approximately 12 feet high by 12 feet wide. We currently offer two machines in the 300 Series: the S327 and the S330. The S327 has a manifold length of 27 feet and the S330 has a manifold length of 30 feet. They typically ship by flat deck, RGN or drop deck trailers for over the road transport. They are very large machines and will require oversize permits for most roads. The FireBox can be either dragged onto the trailer with a winch or lifted onto the trailer. Like all of our FireBoxes, these air curtain burner units can be dragged around the site on their skids. The 300 Series units have two doors at the rear for ash and BioChar removal.

• Safety Systems: Engine over temperature shut down; Loss of cooling fluid shutdown; Loss of oil pressure shutdown; Front deck security enclosure
• Instrument Panel: MBW Electronic engine control with preset throttle settings: key switch, tachometer, hour meter, fuel gauge, oil pressure and water temperature and safety shutdown features
• Transportation & Set-Up: Shipped completely assembled; Ready for immediate use; Lifting pads provided for crane lifting

• Ash clean-out rake with 1” (25 mm) blank steel faceplate, interface to accommodate loader to be attached by end-user